Engineering Transactions, 42, 1-2, pp. 75-84, 1994

On Fatigue Strength Under Out-of-Phase Sinusoidal Loadings

J. Kolenda
Gdańsk University of Technology, Gdańsk
Poland

Let us focus our attention on predicting the influence of phase shifts between sinusoidal stress components of equal frequencies upon the safety factor and the number of cycles-to-failure in fatigue design of structural members made from structural steels. The general state of stress is considered and analyzed by means of the stress-based calculation procedure developed for the case of in-phase stress components. The basic variable space is divided into the safe region and the failure region. In the failure region the subregion of high-cycle fatigue is determined. Functionals of safety are defined, the minimum values of which can be taken as measures of safety in the safe region and in the failure subregion. lt is shown when the phase shift between normal and tangential stress components is most advantageous.

Full Text: PDF

References

J. SZALA and J. SEMPRUCH, Influence of phase shifts between components of a complex load on fatigue crack properties [in Polish], Zesz. Nauk. Pol. Świętokrzyskiej, Mech., 48, 281-289, Kielce 1992.

V. DOQUET and J. WEISS, Multiaxial low cycle fatigue damage of an austenitic and two ferritic steels at 20° C and 600° C, Arch. Mech., 44, 1, 69-84, 1992.

A. SILJANDER, P. KURATH and F.V. LAVRENCE, Multiaxial nonproportional fatigue of weldments, OMAE 90, Proc. 9 th Int. Conf. Offshore Mechanics and Arctic Engng., Houston USA, 18-23 February 1990, 3, 229-238, 1990.

J. KOLENDA, Safety factors and probability of fatigue failure at simultaneous bending, tension and compression, Marine Technology Trans., 1, 65-79, 1989.

J. KOLENDA, Safety factor and reliability index in a general state of cyclic stress, Marine Technology Trans., 3, 119-125, 1992.

J. KOLENDA, Stress-based lifetime prediction method for a general state of cyclic stress, Marine Technology Trans., 3, 127-135, 1992.

A. BLAKE [Ed.], Handbook of mechanics, materials and structures, J. Wiley, New York 1985.

S. KOCAŃDA and J. SZALA, Fundamentals of fatigue analysis [in Polish], PWN, Warszawa 1985.




Copyright © 2014 by Institute of Fundamental Technological Research
Polish Academy of Sciences, Warsaw, Poland